Autoliv Presents Two New Airbags

Autoliv Presents Two New Airbags

(Stockholm, Sweden, June 25, 2007) --- At the international scientific
conference Enhanced Safety of Vehicles (ESV), Autoliv Inc. - the worldwide
leader in automotive safety -  intro¬duced two new airbags that could save
thousands of lives every year and prevent ten times as many severe injuries. 
  The Bumper Airbag for SUVs (Sport Utility Vehicles) addresses the
compatibility problem associated with them and other high-hooded vehicles
colliding with passenger cars and other low-profile vehicles. The Front Edge
Airbag will save the lives of pedestrians when struck by an SUV.

In Europe alone, more than 10,000 pedestrians and other vulnerable road users
are killed every year when struck by a motor vehicle. The EU has therefore
introduced regulations on pedestrian protection and proposed even stricter rules
by 2012. In response, Autoliv introduced a  “pop-up hood” at the 2001 ESV
conference that protects the heads of pedestrians by using airbag technologies
to enable the hood to flex. Autoliv has had this system in serial production for
more than a year. 

However, SUVs are of particular concern for pedestrians due to their higher and
more box-shaped fronts. The fatality risk for pedestrians is 2.5 times higher in
SUV impacts than it is for regular cars. Another difference is the impact area.
While most pedestrians killed by passenger cars perish when they hit their heads
on the hood or windshield area of the car, the majority of severe injuries to
pedestrians caused by SUVs occur when the front hood edge (also called the
Bonnet Leading Edge or BLE) hits the pedestrian's chest and abdomen. Autoliv has
therefore developed an airbag to address this problem. Triggered by a pre-crash
sensor (such as radar), the airbag deploys a few milliseconds before a
pedestrian impact.  

The system has been tested in both computer simulations and in real crash tests,
involving crash dummies representing an average male and a very short female. In
the simulations, the Front Edge Airbag demonstrated its ability to pass the
tough requirements of EuroNCAP, the European crash test organization that rates
new light vehicle models. In the full-scale tests, the airbag decreased all
critical injury values considerably. The largest reduction was for the abdomen
of the male dummy. Here the injury risk was reduced from 99% to just 3% when
using the Front Edge Airbag. The test velocity was 40 km/h (25 mph), which is
the average impact speed in fatal pedestrian accidents. Based on the crash
tests, it is estimated that this new airbag could save hundreds of lives every
year in the United States alone.

New Bumper Airbag
The new Bumper Airbag for SUVs also enhances pedestrian safety by deploying from
beneath the bumper to protect the pedestrian's legs. In the tests, the violence
to the lower legs of the pedestrian dummy was reduced by more than 50% to levels
within the criteria set by the EuroNCAP rating agency in their pedestrian
protection tests.

However, the most important application of the bag will probably be in crashes
when there is a mismatch in the height of the vehicles, especially when an SUV
or other high-profile vehicle “T-bones” a passenger car. In these side impact
collisions, the front of the SUV typically hits above the sill and the
energy-absorbing structure of the passenger car, resulting in critical
intrusions into the passenger  compartment and, in some instances, even in
collapses of the “protection cage” around the car occupants. 


Consequently, crash data indicates that the risk of death in such crashes is
between 27 and 48 times higher in a passenger car than in another SUV. 

40% reduction 
The Bumper Airbag has been evaluated in computer simulations and real crash
tests. This 1.5 meter long, tubular airbag was mounted under the bumper of a
Ford Explorer that was run head-on into the side of a typical passenger car at
48 Km/h (30 mph). The bag inflation started 80 milliseconds before the impact,
using a pre-crash sensor, and the bag's load carrying structure swung into
position. The intrusions were significantly less at all measuring points with
the Bumper Airbag. At the level of the head of an occupant, the reduction was as
much as 40%. An added benefit indicated by the tests was that the time available
to inflate the side airbags of the passenger car could be increased when the SUV
is equipped with a bumper bag.

The benefits of less intrusion using a Bumper Airbag are in the process of being
evaluated using sled tests and crash test dummies. These tests indicate that the
risk for rib fractures and other severe or fatal injuries (so called AIS3+
injuries) to the upper body could be reduced by nearly 40%. So far, only the
benefits to the upper body have been evaluated. However, since the reduction at
the head level was more significant than for other body parts, it can be assumed
that the bumper bag could be even more efficient in reducing head injuries than
the estimated 40% reduction in rib fractures and injuries to the lungs and the
aorta recorded in the tests. 

The preliminary estimates therefore indicate that this new airbag could save
approximately 1,000 lives annually in the United States alone. 

ESV Conference
The Enhanced Safety of Vehicles (ESV) is the world-leading scientific forum for
vehicle safety. It is organized every second year by the National Highway
Traffic Safety Administration (NHTSA) in the United States. NHTSA is also
responsible for ESV's scientific secretariat. 

At this year's conference, which was held in Lyon, France, Autoliv presented
five scientific papers. In addition to the two papers on the new airbags,
Autoliv representatives presented an evaluation on child restraints and another
paper on Biorid (Bio-fidelic Rear-Impact Dummy). This dummy is more human-like
than previous crash-test dummies, and will be used in EuroNCAP's proposed
whiplash protection tests in rear-impacts. The fifth ESV-paper from Autoliv
shows how pretensioners and other seatbelt improvements can reduce the risk for
chest injuries. All papers are available on Autoliv's corporate website
www.autoliv.com at What we do - Research - Reports & Papers.

Inquiries: 
Rikard Fredriksson, Leader Pedestrian Protection Projects, Cell phone +46-733-61
43 76
Bengt Pipkorn, Leader Bumper Airbag Project,  Cell phone +46-733-61 43 41


For high-resolution images please contact info@autoliv.com
For more information on ESV: http://www-esv.nhtsa.dot.gov/

Autoliv Inc., the worldwide leader in automotive safety systems, develops and
manufactures automotive safety systems for all major automotive manufacturers in
the world. Together with its joint ventures, Autoliv has 80 facilities with
approximately 42,000 employees in 28 vehicle-producing countries. In addition,
the Company has technical centers in twelve countries around the world,
including 21 test tracks, more than any other automotive safety supplier. Sales
in 2006 amounted to US $6.2 billion. The Company's shares are listed on the New
York Stock Exchange (NYSE: ALV) and its Swedish Depository Receipts on the
Stockholm Stock Exchange (SSE: ALIV).